资源预览内容
第1页 / 共3页
第2页 / 共3页
第3页 / 共3页
亲,该文档总共3页全部预览完了,如果喜欢就下载吧!
资源描述
环氧铁红车间底漆的用途和使用环氧铁红车间底漆的用途和使用Intended Uses用途用途环氧铁红车间底漆环氧铁红车间底漆属于防腐涂料,经抛丸或喷砂后的钢材作保养底漆,保养期可 达 3-6 个月,也可用钢结构贮藏底漆使用,是一种常温固化的车间底漆,干燥快, 物理机械性能优良,能和各类底漆配套,由于不含金属锌等物质,故能减少焊接 产生的气体危害Suited for steel shot or grit blasted shop primer with 3-6 months of maintenance period and for steel structure tank as primer as well. Curing at ambient temperature. Quick dry, excellent physical and mechanical properties. It is able to match with all the primer and may reduce harm of gas risen from electro-welding owing to no zinc etc in them ProductInformation 产品简介产品简介双组分,铁红色Two packages, Iron redVolume Solids 固体份25%Dry Film Thickness 干膜厚度25 microns equivalent to 100 microns of wet film25 微米相当于 100 微米湿膜厚 Theoretical Coverage 理论涂布率8.7m2 /Kg 8.7 平方米/公斤Application details产品数据产品数据Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗 Mix Radio 混合比A : B=15:6.4(by weight) 甲:乙=15:6.4 Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用Conventional Spray 传统喷涂 Not Recommended 不推荐采用 Thinner 稀释剂 C006 Maximum thining:5%最大稀释量:5% C006 Cleaner 油漆设备清洗剂 COO6 Pot Life 使用期 2 5:24h 2 5约 24 小时Storage and Handling施工详述施工详述Storage 贮存期 One year 一年Over coating Interval覆涂间隔SubstrateTemperature底材温度,Touch Dry表干(h)Hard Dry硬干(h)Mix 最短Max 最长 Drying time 干燥时间2521616 h3months Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;15Kg in 20 liter container 甲:15 公斤装于 20 公升容器 中B:6.4Kg in 10 liter container 乙:6.4 公斤装 10 公升容器中Storage andHandling贮存与管理贮存与管理Specific Gravity 比重 Approx1.15Kg/L 大约 1.15 公斤/公升来源 江苏纽克莱涂料有限公司 http:/www.nsk-paint.comLimitations限制限制 Recommend coat: Spray one coat with high-pressure airless spray for the purpose of reaching 20-25 microns of dry film thickness.Subsequent coat: Epoxy resin paint, coal-tar epoxy paint, chlorinated rubber paint, alkyd resin paint. Phenolic resin paint, chlorosulphonated polythylene anticorrosive paint and rlighly chloronated polyeerylene anticorrosive paint etc.环氧铁红车间底漆环氧铁红车间底漆建议涂装道数:高压无空气喷涂一道,干膜厚度达 20-25 微米后道配套涂料:环氧树脂涂料、环氧沥青涂料、氯化橡胶涂料、醇酸树脂涂料、 酚醛树脂涂料、氯磺化聚乙烯防腐涂料、高氯化聚乙烯防腐涂料。The product must be used in painting area by professionals. When painting, please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application sites. In order to remove any danger of SafetyPrecautions安全措施安全措施explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.参考 http:/www.ahaozhe.comNOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will NOT be responsible for any accident.环氧铁红车间底漆环氧铁红车间底漆必须由专业人员在工业场所使用。使用时请务必参照本说明 书以及相关健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健 康安全知识,请与本公司人员联系。该涂料为溶剂型涂料,为避免事故或危险发生,应采取最低限度的安全措施如下:此涂料为易燃物,并含有挥发性易燃溶剂,故必须远离火星和明火。严禁在作业场所吸烟,并应该采取有效措施,防止火星产生(如采用防爆电器设备, 杜绝静电积累,避免金属撞击等)。施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风 量以维持气体/空气比例不超过最低爆炸极限的 10 %,通常每千克溶剂需要 200 立 方米通风量,(与溶剂种类相关)就能维持最低爆炸极限 10 %的工作环境。 采取有效措施,防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩 及涂防护油等)。若皮肤不慎与产品相接触,请用清水及肥皂或适当的工业清洁剂 彻底清洗;若眼睛受到污染,请即刻用清水冲洗至少 10 分钟,并立即就医。环氧铁红车间底漆环氧铁红车间底漆施工时,建议佩戴面罩以免吸入漆雾和有害气体,尤其在通风 不良的环境下,更要注意。最后请谨
网站客服QQ:2055934822
金锄头文库版权所有
经营许可证:蜀ICP备13022795号 | 川公网安备 51140202000112号