? ? CPIK?Frequency?Inverter? ? Operating?Manual? ? Non-Regenerative? 11M 15M 32M 48M 60 105? 15RM 32RM 48RM? Regenerative? 25R 33R 50R 100R 150R? ? A?company?of? ThyssenKrupp? Elevator? ThyssenKrupp?Elevator?(Korea)? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)? i Printers imprint All rights reserved Copyright by: ThyssenKrupp Elevator (Korea) Ltd. 55-30, Oryu-dong, Kuro-Ku, Seoul Printed in Korea, September 2006 The right of reprint or reproduction, even in the case of only partly exploitation, is subject to express, written permission of ThyssenKrupp Elevator (Korea) Ltd Any reproduction, copying or storing in data processing machines in any form or by any means without prior permission of ThyssenKrupp Elevator (Korea) Ltd. is regarded as infringement of the current Copyright Act and will be prosecuted. Technical modifications for reasons of improvement or higher safety standard are subject to decisions of ThyssenKrupp Elevator (Korea) Ltd. without prior notice. The responsibility for the content lies with the editor: ThyssenKrupp Elevator (Korea) Ltd. Preface We are pleased that you decided to purchase a quality product from ThyssenKrupp Elevator (Korea) Ltd. This operating manual assists you in getting familiar with the frequency inverter and its intended possibilities of use. Important information concerning safety and hazards helps you to safely use the frequency inverter as intended. Subject to technical alteration. ? ? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)? ii TABLE?OF?CONTENT? ? 1.?SAFETY?1? 1.1?Explanation?of?symbols?used.?1? 1.2?General?safety?information?2? 2.?PRODUCT?DESCRIPTION?AND?INSTALLATION?INSTRUCTIONS.?5? 2.1?Representation?of?frequency?inverter?CPIK.?5? 2.2?Description?of?frequency?inverter?CPIK?6? 2.2.1?Warnings?6? 2.2.2?Mounting?instructions.?7? 2.2.3?Technical?data?8? 2.2.3.1?General?data.?8? 2.2.3.2?Type?specification.?9? 2.2.3.3?External?modules?10? 2.2.3.4?Derating?10? 2.2.4?General?instructions.?10? 2.2.4.1?Mains?voltage.?10? 2.2.4.2?System?configuration.?11? 2.2.4.3?Mains?connection.?11? 2.2.4.4?Isolation?of?frequency?inverter.?11? 2.2.4.5?Leakage?current?11? 2.2.4.6?Fault?current.?11? 2.2.4.7?Discharge?time?of?DC?link?capacitors?11? 2.2.4.8?Electronic?ground?11? 2.2.4.9?Run?Contactor.?11? 2.2.4.10?Internal?fan?11? 2.3?Interface.?12? 2.3.1?Connection?diagram.?12? 2.3.2?Frequency?inverter?Input?and?Output?terminals?(Non-Regenerative).?12? 2.3.2.1?Mains?12? 2.3.2.2?Motor?and?Cables.?12? 2.3.2.3?Braking?resistor?12? 2.3.2.4?Internal?voltage.?12 2.3.2.5?Separately?driven?motor?fan.?13 2.3.2.6?Motor?PTC?thermistor?connection.?13 2.3.2?Frequency?inverter?Input?and?Output?terminals?(Regenerative).?13 ? ? ? ? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)? iii TABLE?OF?CONTENT? 2.3.2.1?Mains?13 2.3.2.2?Motor?and?Cables.?13? 2.3.4?Encoder?connection?and?CAN?communication?14? 2.3.4.1?Encoder?connection.?14? 2.3.4.2?Encoder?signals?and?CAN?communication?to?control.?14? 2.3.4.3?Using?the?CAN?interface?to?connect?the?TCM?(or?TAC50K)?control?system?14? 2.3.4.4?Switching?sequence?chart?with?TCM?control?16? 2.3.4.5?Switching?sequence?chart?with?TAC50K?control.?17? 2.3.5?Interface?to?the?lift?control.?18 2.3.5.1?Ready?message.?18 2.3.5.2?Inputs?and?outputs?18 2.3.5.3?Switching?sequence?chart.?19 2.4?System?perturbations,?EMC.?20 2.4.1?General?20 2.4.2?Mounting?Instructions.?20 2.4.3?Line?choke?20 2.4.4?Line?filter?20 2.4.5?Installation?of?other?cables?20 2.5?Dimension?sheet?21 2.5.1?Dimension?of?CPIK?series?21 2.5.2?External?modules.?22 2.5.2.1?DC?choke.?22 2.5.2.2?Line?filter?(standard,?not?used?IT?lines).?23 2.5.2.3?Line?choke?25 3.?TRANSPORT?AND?STORAGE.?2 2 2 26 6 6 6 ? ? 3.1?General?26 4.?PUTTING?INTO?OPERATION?2 2 2 28 8 8 8 ? ? 4.1?Safety?instructions.?28 4.2?Operating?instructions?28 4.3?Points?to?be?observed?prior?to?initial?powering?on?28 4.4?Checking?the?visual?displays?in?the?event?of?errors?28 4.5?Input?of?lift-specific?values.?29 4.6?Testing?the?drive?for?correct?functioning.?29 4.7?Drive?optimization?30 4.8?Measuring?and?setting?31 4.8.1?LED?and?measuring?points?on?TMI2?board?31 4.8.2?LED?and?measuring?points?on?RMC?board?32 4.8.3?LED?and?measuring?points?on?RMBK?board?(Regenerative?type).?33 ? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)? iv TABLE?OF?CONTENT? 5.?PARAMETER?ENTRY.?3 3 3 34 4 4 4 5.1?General?34 5.2?Operation.?34 5.2.1?Display?and?change?of?parameters.?34 5.2.2?Display?parameters?35 5.2.3?Save?changed?parameters?to?EEPROM.?35 5.2.4?All?parameters?as?factory-set?35 5.2.5?Individual parameters as factory-set?36 5.3?Error?stacks.?36 5.3.1?Display?error?stack.?36 5.3.2?Delete?error?stack?36 5.3.3?End?error?stack?36 5.3.4?Error?description?36 5.4?Parameters.?36 5.4.1?Variable?parameters.?36 5.4.2?Display?parameters?45 6.?SHORT-RUN?DEVICE?4 4 4 48 8 8 8 6.1?General?48 6.2?Settings?48 7.?MODERNIZATION.?50505050 7.1?General?50 7.2?Modernization?by?encoder?mounted?on?motor?shaft?50 7.2.1?Rating?50 7.2.2?Motor?adaptation.?50 7.